CDGYC - CARBON DIOXIDE
- MSDS: CDGYC
- Manufacturer: ANSUL FIRE PROTECTION WORMALD U S INC
- Product Name: CARBON DIOXIDE
- National Stock Number: 4810-01-286-9764
Product Identification
Product ID:CARBON DIOXIDE
MSDS Date:01/12/1996
FSC:4810
NIIN:01-286-9764
MSDS Number: CDGYC
Responsible Party
MARINETTE, WI 54143-2542
US
Emergency Phone: 715-735-7411...TOM LAWSON EXT 580
Info Phone: 715-735-7411...FAX 715-732-3477
Cage: 03670
Contractor
Telephone: 516-887-7943
Cage: 0GKF8
Ingredients
CARBON DIOXIDE
CAS: 124-38-9
RTECS: FF6400000
Fraction By Weight: 100%
OSHA PEL 5000 PPM
ACGIH TLV: 5000PPM/30000STEL;96
Hazards
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE-CONTACT WITH COLD VAPOR/SOLID
CARBON DIOXIDE CAN CAUSE EYE/SKIN FROSTBITE AND FREEZE BURNS.
ASPHYXIANT BY INHALATION & HEAVIER THAN AIR. CAN CAUSE SUFFOCATION
BY REDUCING OXYGEN AVAILABLE. BREAT HING HIGH CONCENTRATIONS WILL
CAUSE LIGHTHEADEDNESS, SHORTNESS OF BREATH. INGESTION IS UNLIKELY.
CHRONIC-UNKNOWN.
Explanation of Carcinogenicity:MFR GAVE THE ABOVE LISTINGS ON THE MSDS
BUT NO OTHER COMMENTS WERE RECORDED.
Effects of Overexposure:DIZZINESS, IMPAIRED COORDINATION, REDUCED
MENTAL ACUITY, HEADACHES, TINNITUS, DIFFICULTY BREATHING, AND/OR
DROWSINESS DEPENDING ON LENGTH OF EXPOSURE & CONCENTRATIONS.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS
First Aid
First Aid:IF ANY IRRITATION PERSISTS OR SEVERE, GET MEDICAL ATTENTION.
TREAT FOR FROSTBITE IF NECESSARY. EYE-FLUSH W/WATER FOR 15 MIN.
SKIN-WASH W/SOAP & WATER. INHALED-REMOVE FROM CONTAMINATED AREA. IF
SYMPTOM S OCCUR, CONSULT MEDICAL PERSONNEL. AIDOR RESTORE BREATHING
AS NEEDED. INGESTED-MFR GAVE NO INFORMATION ON MSDS.
Fire Fighting
Flash Point:NONE
Extinguishing Media:THIS IS AN EXTINGUISHING AGENT. HMIS:USE
EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE - THIS IS AN EXTINGUISHING AGENT.
Unusual Fire/Explosion Hazard:THOUGH GAS CYLINDERS ARE EQUIPPED WITH
PRESSURE AND TEMPERATURE RELIEF DEVICES, THEY SHOULD BE REMOVED
FROM HIGH TEMPERATURES OR FIRE TO AVOID RISK OF RUPTURE.
Accidental Release
Spill Release Procedures:EVACUATE PERSONNEL. VENTILATE TO OUTSIDE
ATMOSPHERE. COOL OR REMOVE HOT, METAL SURFACES OR SOURCE OF NON-
EXTINGUISHED FLAMES.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
Handling
Handling and Storage Precautions:STORE IN A CEAN, DRY, WELL-VENTILATED
AREA AWWAY FROM HEAT ABOVE 120F. STORE AS A COMPRESSED GAS IN DOT
APPROVED VESSELS.
Other Precautions:IF NOT ATTACHED TO A SYSTEM, CYLINDER/CARTRIDGE MUST
BE SAFETY CAPPED TO PROTECT AGAINST VIOLENT VELLEL MOVEMENT OR
FORCE OF EXCAPING GAS IF VALVE IS ACTUATED OR SEAL IS PUNCTURED.
NOTE INCOMPATIBILIT Y INFORMATION.
Exposure Controls
Respiratory Protection:NOT NORMALLY NECESSARY IF CONTROLS ARE ADEQUATE.
IF TLV IS EXCEEDED OR IF EXPOSURE IS PROLONGED, A SELF-CONTAINED
BREATHING APPARATUS IS RECOMMENDED.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS RECOMMENDED W/LOCAL
EXHAUST RECOMMENDED FOR CONFINED SPACES.
Protective Gloves:FOR CONTACT W/DRY ICE
Eye Protection:CHEMICAL GOGGLES + FACE SHIELD
Other Protective Equipment:PROTECTIVE CLOTHING FOR CONTACT W/DRY ICE.
Work Hygienic Practices:MFR:?. HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICES. AVOID CONTACT IF AT ALL POSSIBLE. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
P/N ON CTDF: 17284; P/N GIVEN BY DDRV ON TECH SUPPORT SHEET: 17492.
Chemical Properties
HCC:G3
Boiling Pt:B.P. Text:SUBLIMES
Vapor Pres:42928 MMHG
Vapor Density:1.5
Spec Gravity:1.98
Evaporation Rate & Reference:GAS AT ROOM TEMPERATURE
Solubility in Water:APPRECIABLE
Appearance and Odor:COLORLESS GAS WITH NO ODOR.
Percent Volatiles by Volume:100
Stability
Stability Indicator/Materials to Avoid:YES
REACTS VIGOROUSLY W/(AL+NA2O2), CS2O, LI, K, MG(C2H5) 2, (MG+NA2O),
KHC2, NA, NA2C2, NAK, TI
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
Disposal
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.